Oversizing an AODD pump is a common mistake — but undersizing is arguably worse. An oversized pump wastes compressed air and accelerates diaphragm wear through overwork. An undersized pump does...
Dosing Technologies
Auto-Dosing Unit
Compact Dosing, Built to Run Unattended
An Auto-Dosing Unit (ADU) pairs a peristaltic dosing pump with a timer, controller, or programmable circuit board inside a single, wall-mountable enclosure. The peristaltic pump moves chemical by compressing a flexible tube against a rotor — a simple mechanism with no seals or check valves in contact with the fluid, which suits viscous, corrosive, or particulate-laden liquids well. The controller decides when and how much to dose: on a repeating schedule, on a signal from host equipment, or from a live process reading.
Peristaltic dosing — a rotor compresses a flexible tube to move chemical, so no pump seals are exposed to the fluid being dosed
Timer or controller-driven — dosing follows a programmable schedule, an external signal, or a live pH/ORP/chlorine reading, depending on the application
Compact and self-contained — pump and control electronics share one IP65-rated enclosure, ready for wall mounting near the point of use
Four application types — Self-Service Laundry, Enzyme Dosing, Dishwashing, and Swimming Pool, each matched to its own dosing profile
Browse by Application
All Application Types
Peristaltic Pump + Controller
Self-Service Laundry ADU
Dosing units for coin-op and self-service laundromats, dispensing detergent and softener into each wash cycle on a timed or signal-triggered basis. Multi-pump controllers run several wash programmes from one unit.
Peristaltic Pump + Controller
Enzyme Dosing ADU
Timed enzyme dosing for grease traps and drain lines in commercial kitchens, breaking down FOG (fats, oils and grease) and keeping lines clear. A weekly programmable timer schedules dosing automatically, with no daily intervention required.
Peristaltic Pump + Controller
Dishwashing ADU
Dual-pump dosing units for professional dishwashers, metering detergent and rinse aid independently, each set to match wash chemistry and rinse-cycle requirements.
Peristaltic Pump + Controller
Swimming Pool ADU
Digital pH, ORP and free-chlorine dosing controllers for pool water treatment, using dosing pumps driven by live probe readings to keep pool chemistry within range automatically.
Stay Informed
Latest Resources
Inline Medicator vs Batch Preparation: Why Your Header Tank Is Undermining Your Livestock Medication Programme
Walk into almost any poultry or swine house in Malaysia and you will find the same setup: a header tank sitting above the waterline, filled with a pre-mixed batch of...
Bare Gold Electrode vs Membrane-Type Sensors for Oxidizer and Reducing Agent Measurement
Most inline chlorine and oxidizer sensors on the market share the same weak point: a membrane. It sits between the electrode and the water, and it’s also the part that...
How Boiler Blowdown Frequency Affects Steam Quality and Chemical Consumption
Every boiler accumulates dissolved solids. The feedwater entering the boiler contains dissolved minerals — calcium, magnesium, silica, sodium, chloride, and others — that do not follow the steam into the...
Mechanical Seal vs. Magnetic Drive for Chemical Transfer: The Decision Is Not Just About Leakage
Every pump selection guide eventually arrives at the same question: mechanical seal or magnetic drive? The shorthand answer — “mag drive is safer for hazardous chemicals” — is right as...
Why Biofilm in a Cooling Tower Is a Fundamentally Different Problem Than Planktonic Bacteria
When cooling tower water treatment programmes fail to control Legionella or other microbial threats, the instinct is usually to dose more biocide. Sometimes this works. Often it does not —...