Most irrigation system problems are not equipment problems. They are design problems — decisions made before a single pipe was laid that locked in inefficiency, inconsistency, or maintenance headaches that...
Dosing Technologies
Auto-Dosing Unit
Compact Dosing, Built to Run Unattended
An Auto-Dosing Unit (ADU) pairs a peristaltic dosing pump with a timer, controller, or programmable circuit board inside a single, wall-mountable enclosure. The peristaltic pump moves chemical by compressing a flexible tube against a rotor — a simple mechanism with no seals or check valves in contact with the fluid, which suits viscous, corrosive, or particulate-laden liquids well. The controller decides when and how much to dose: on a repeating schedule, on a signal from host equipment, or from a live process reading.
Peristaltic dosing — a rotor compresses a flexible tube to move chemical, so no pump seals are exposed to the fluid being dosed
Timer or controller-driven — dosing follows a programmable schedule, an external signal, or a live pH/ORP/chlorine reading, depending on the application
Compact and self-contained — pump and control electronics share one IP65-rated enclosure, ready for wall mounting near the point of use
Four application types — Self-Service Laundry, Enzyme Dosing, Dishwashing, and Swimming Pool, each matched to its own dosing profile
Browse by Application
All Application Types
Peristaltic Pump + Controller
Self-Service Laundry ADU
Dosing units for coin-op and self-service laundromats, dispensing detergent and softener into each wash cycle on a timed or signal-triggered basis. Multi-pump controllers run several wash programmes from one unit.
Peristaltic Pump + Controller
Enzyme Dosing ADU
Timed enzyme dosing for grease traps and drain lines in commercial kitchens, breaking down FOG (fats, oils and grease) and keeping lines clear. A weekly programmable timer schedules dosing automatically, with no daily intervention required.
Peristaltic Pump + Controller
Dishwashing ADU
Dual-pump dosing units for professional dishwashers, metering detergent and rinse aid independently, each set to match wash chemistry and rinse-cycle requirements.
Peristaltic Pump + Controller
Swimming Pool ADU
Digital pH, ORP and free-chlorine dosing controllers for pool water treatment, using dosing pumps driven by live probe readings to keep pool chemistry within range automatically.
Stay Informed
Latest Resources
The Hidden Cost of Oversizing an AODD Pump: Air Consumption, Heat, and Diaphragm Life
Selecting a pump one size up “just to be safe” is one of the most common and costly mistakes in AODD pump applications. An oversized AODD pump does not simply...
AODD Pump Ball and Seat Maintenance: When to Clean, When to Replace
The balls and seats are the check valves in an AODD pump. They control the direction of fluid flow — open on intake, closed on discharge. When they wear or...
The Consequences of Running a Mag Drive Pump with Suspended Solids
Magnetic drive centrifugal pumps are specified for hazardous chemical transfer because they seal completely — no shaft penetration, no dynamic seal, no potential leak path. But that sealed containment shell...
Piston Motor vs. Diaphragm Motor in a Dosatron: Which One Fails First in Hard Water?
Hard water is one of the most common reasons a Dosatron unit starts dosing inconsistently or stops working altogether. The mechanism is straightforward: calcium and magnesium carbonates precipitate out of...
Pumping Slurries with an AODD Pump: How Ball Seat Geometry Affects Solids Passage and Seal Life
AODD pumps handle slurries better than most other pump types — no mechanical seal to abrade, no close-clearance impeller to jam, no shaft to deflect under asymmetric particle loads. But...