Magnetic drive centrifugal pumps are specified for hazardous chemical transfer because they seal completely — no shaft penetration, no dynamic seal, no potential leak path. But that sealed containment shell...
Dosing Technologies
Auto-Dosing Unit
Compact Dosing, Built to Run Unattended
An Auto-Dosing Unit (ADU) pairs a peristaltic dosing pump with a timer, controller, or programmable circuit board inside a single, wall-mountable enclosure. The peristaltic pump moves chemical by compressing a flexible tube against a rotor — a simple mechanism with no seals or check valves in contact with the fluid, which suits viscous, corrosive, or particulate-laden liquids well. The controller decides when and how much to dose: on a repeating schedule, on a signal from host equipment, or from a live process reading.
Peristaltic dosing — a rotor compresses a flexible tube to move chemical, so no pump seals are exposed to the fluid being dosed
Timer or controller-driven — dosing follows a programmable schedule, an external signal, or a live pH/ORP/chlorine reading, depending on the application
Compact and self-contained — pump and control electronics share one IP65-rated enclosure, ready for wall mounting near the point of use
Four application types — Self-Service Laundry, Enzyme Dosing, Dishwashing, and Swimming Pool, each matched to its own dosing profile
Browse by Application
All Application Types
Peristaltic Pump + Controller
Self-Service Laundry ADU
Dosing units for coin-op and self-service laundromats, dispensing detergent and softener into each wash cycle on a timed or signal-triggered basis. Multi-pump controllers run several wash programmes from one unit.
Peristaltic Pump + Controller
Enzyme Dosing ADU
Timed enzyme dosing for grease traps and drain lines in commercial kitchens, breaking down FOG (fats, oils and grease) and keeping lines clear. A weekly programmable timer schedules dosing automatically, with no daily intervention required.
Peristaltic Pump + Controller
Dishwashing ADU
Dual-pump dosing units for professional dishwashers, metering detergent and rinse aid independently, each set to match wash chemistry and rinse-cycle requirements.
Peristaltic Pump + Controller
Swimming Pool ADU
Digital pH, ORP and free-chlorine dosing controllers for pool water treatment, using dosing pumps driven by live probe readings to keep pool chemistry within range automatically.
Stay Informed
Latest Resources
When to Use PVDF Instead of Polypropylene or Stainless Steel in an AODD Pump
An AODD pump body sees more sustained chemical exposure than almost any other wetted component in a plant. Pick the wrong material and you don’t get a slow, manageable decline...
Mechanical Seal vs. Magnetic Drive for Chemical Transfer: The Decision Is Not Just About Leakage
Every pump selection guide eventually arrives at the same question: mechanical seal or magnetic drive? The shorthand answer — “mag drive is safer for hazardous chemicals” — is right as...
Pre-Bleed Lockout and Lockout Period: Why These Two Controller Features Matter for Cooling Tower Treatment Accuracy
Cooling tower water treatment controllers are most commonly evaluated on what they can control — conductivity setpoints, biocide dosing schedules, pH management. What is less often discussed is what they...
Why There Is No Single Way to Measure COD — and What That Means for Your Water Monitoring Programme
Chemical oxygen demand is one of the most universally reported parameters in industrial water quality management. It appears on discharge consent conditions, in process control targets, and in environmental compliance...
When Your AODD Pump Freezes: Understanding Air Exhaust Icing and How to Prevent It
Your AODD pump slows down, chokes, and stops — but only on humid days, or only in the morning, or only when the compressor has been running hard. The pump...