Your AODD pump stalls. You check the air pressure — it reads fine at the regulator. You check the diaphragms — intact. You check the pneumatic exchanger — no obvious...
Dosing Technologies
Auto-Dosing Unit
Compact Dosing, Built to Run Unattended
An Auto-Dosing Unit (ADU) pairs a peristaltic dosing pump with a timer, controller, or programmable circuit board inside a single, wall-mountable enclosure. The peristaltic pump moves chemical by compressing a flexible tube against a rotor — a simple mechanism with no seals or check valves in contact with the fluid, which suits viscous, corrosive, or particulate-laden liquids well. The controller decides when and how much to dose: on a repeating schedule, on a signal from host equipment, or from a live process reading.
Peristaltic dosing — a rotor compresses a flexible tube to move chemical, so no pump seals are exposed to the fluid being dosed
Timer or controller-driven — dosing follows a programmable schedule, an external signal, or a live pH/ORP/chlorine reading, depending on the application
Compact and self-contained — pump and control electronics share one IP65-rated enclosure, ready for wall mounting near the point of use
Four application types — Self-Service Laundry, Enzyme Dosing, Dishwashing, and Swimming Pool, each matched to its own dosing profile
Browse by Application
All Application Types
Peristaltic Pump + Controller
Self-Service Laundry ADU
Dosing units for coin-op and self-service laundromats, dispensing detergent and softener into each wash cycle on a timed or signal-triggered basis. Multi-pump controllers run several wash programmes from one unit.
Peristaltic Pump + Controller
Enzyme Dosing ADU
Timed enzyme dosing for grease traps and drain lines in commercial kitchens, breaking down FOG (fats, oils and grease) and keeping lines clear. A weekly programmable timer schedules dosing automatically, with no daily intervention required.
Peristaltic Pump + Controller
Dishwashing ADU
Dual-pump dosing units for professional dishwashers, metering detergent and rinse aid independently, each set to match wash chemistry and rinse-cycle requirements.
Peristaltic Pump + Controller
Swimming Pool ADU
Digital pH, ORP and free-chlorine dosing controllers for pool water treatment, using dosing pumps driven by live probe readings to keep pool chemistry within range automatically.
Stay Informed
Latest Resources
Smart Paddy Farming: How IoT Sensors Are Closing Malaysia’s Data Gap
Most paddy fields in Malaysia are still managed the same way they were a generation ago: irrigate on a fixed schedule, apply fertiliser by habit, and check for pests by...
Hose Life in a Peristaltic Pump: How Compression Set, Chemical Attack, and RPM Interact
The hose in a peristaltic pump is the only consumable that matters. Everything else — the rotor, the casing, the drive — runs for years without replacement. The hose typically...
Why Your AODD Pump Stalls at Deadhead — And What It Tells You About Your System Design
Your AODD pump runs, the downstream valve closes, and the pump goes quiet. That is deadhead behaviour — and it is supposed to happen. What most operators do not realise...
Why Ball Material Selection in an AODD Pump Is Not Just a Chemical Compatibility Decision
When engineers specify an AODD pump, ball material is usually the last thing on the selection checklist. The body material gets careful attention. The diaphragm gets reviewed against the chemical...
3 Mistakes That Cause Premature AODD Pump Failure — And How to Avoid Them
The AODD pump is one of the most commonly used chemical transfer pumps in Malaysian industry. Walk into any factory that handles chemicals in significant quantities — gloves, oleochemical, water...